Char-Broil 461111811 - Manuals

Page 2 - TABLE OF CONTENTS; Indicates an imminently hazardous situation; WARNING; CAUTION; Indicates a potentially hazardous situation or; CAUTION; THIS GRILL IS FOR OUTDOOR USE ONLY.; DANGER; of any flammable liquid.; • For residential use only. Not intended for commercial use.; CAUTION; Wash your hands after handling this product.; WARNING

Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Safety Symbols . . . . . . . . . . ....

Page 3 - Safety Tips; If you have a grill problem see the Troubleshooting Section.; USE AND CARE; For Safe Use of Your Grill and to Avoid Serious; • Use grill at least 2 ft. from any wall or surface.; • Never use regulator from this grill with any other LP

3 Installation Safety Precautions• Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. • Grill installation must conform with local codes, or in their absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ NFPA 54 . Storage and handlin...

Page 4 - Propane Cylinder Installation/Removal; Propane Gas Cylinders

4 LP (Liquefied Petroleum Gas) • For Your Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air. Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. Propane Cylinder Use (1 lb. Disposa...

Page 5 - Lighting Instructions; Important! Remove or raise lid to open position.; Burner Flame Check; IF YOU EXPERIENCE THE FOLLOWING:

5 Lighting Instructions Important! Remove or raise lid to open position. Attempting to light burner with lid closed may cause anexplosion. Do not expose any part of your body or clothing directly above cooking area when lighting. 1. From beneath the grill, place lighted wooden match up through light...

Page 6 - Grill Maintenance; DO NOT; • Putting out grease fires by closing the lid is not possible.; Before Cooking For The First Time

Grill Maintenance - Allow grill to cool before cleaning. Frequency of cleaning is determined by how often grill is used. - DO NOT use self-cleaning oven to clean any grill part. Extreme heat would remove any chrome plating and cause premature rusting. - Meat drippings will solidify in bottom of gril...

Page 7 - LIMITED WARRANTY

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...

Page 8 - Tools required for assembly:; Adjustable Wrench - Not provided; Hardware is shown actual size.; Phillips screwdriver - Not provided; Parts List; Not Shown

Key Qty Description A 1 Lid Handle B 1 Lid C 2 Lid Support Bracket D 1 Cooking Grate E 1 Heat Distribution Plate F 1 Burner G 1 Heat Resistant Shield H 1 Bottom I 2 Side Handle J 1 Regulator/Valve K 2 Leg Tools required for assembly: Adjustable Wrench - Not provided NOTE: Some grill parts shown in t...

Page 9 - Assembly

HEAT RESISTANT SHIELD (G) BOTTOM (H) 1/4-20 x 3/8” SCREW (M) LEG (K) Assembly - Position Heat Shield (G) as shown at right below and place into Bottom (H). - Insert narrow end of Burner (F) through large hole in side of Bottom (H) and rest burner bracket on Shield (G). - Insert one 1/4-20 x 3/8” Scr...

Page 12 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Prevention/Solution is turned on. Troubleshooting Possible Cause Problem Burner will not Light. Flames burns out on “LOW”. • Out of Propane • Regulator not fully tightened to cylinder. • Insp...