Page 2 - TAbLE Of CONTENTS
100882 - CULTivATOR TAbLE Of CONTENTS 2 TAbLE Of CONTENTS introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Safety Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 important Safety ins...
Page 3 - SAfETY DEfiNiTiONS; DANGER; iNTRODUCTiON; CPE TECHNICAL SUPPORT TEAM
100882 - CULTivATOR iNTRODUCTiON 3 SAfETY DEfiNiTiONS The purpose of safety symbols is to attract your attention to possible dangers. The safety symbols, and their explanations, deserve your careful attention and understanding. The safety warnings do not by themselves eliminate any danger. The instr...
Page 4 - iMPORTANT SAfETY iNSTRUCTiONS; WARNiNG; CAN KILL YOU IN MINUTES; Things to Do
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 4 iMPORTANT SAfETY iNSTRUCTiONS WARNiNG Cancer and Reproductive Harm – www.P65Warnings.ca.gov DANGER Using an engine indoors CAN KILL YOU IN MINUTES . Engine exhaust contains carbon monoxide. This is a poison you cannot see or smell. NEVER use in...
Page 5 - Things Not to Do
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 5 – To reduce fire hazard, keep the engine, and petrol/gas storage area free of vegetative material and excessive grease. – Start the engine carefully, according to the instructions and with feet well away from the tines. – Always operate the cultiva...
Page 6 - fuel Safety
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 6 fuel Safety DANGER GASOLINE AND GASOLINE VAPORS ARE HIGHLY FLAMMABLE AND EXPLOSIVE. Fire or explosion can cause severe burns or death. Gasoline and gasoline vapors: – Gasoline is highly flammable and explosive. – Gasoline can cause a fire or expl...
Page 7 - Safety and Dataplate Labels; LABEL
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 7 Safety and Dataplate Labels These labels warn you of potential hazards that can cause serious injury. Read them carefully. If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement. LABEL DESCRIPTION A WA...
Page 8 - Safety Symbols; SYMBOL; before using this product.; Eye and Ear Protection.; Avoid injury from rotating tines. Keep hands away.
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 8 Safety Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product. SYMBOL MEANING Read Operator’s Manual. To...
Page 9 - Operation Symbols; Quickstart Label Symbols; NOTiCE
100882 - CULTivATOR iMPORTANT SAfETY iNSTRUCTiONS 9 Operation Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product. SYMBOL MEANING Choke Run Throttle Leve...
Page 10 - CONTROLS AND fEATURES; Cultivator
100882 - CULTivATOR CONTROLS AND fEATURES 10 CONTROLS AND fEATURES Read this operator’s manual before operating your cultivator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Cultivator 1. Fender Guard 2. Fuel Tank – 0.3 gal....
Page 11 - Parts included; Assembly Parts
100882 - CULTivATOR CONTROLS AND fEATURES 11 Parts included Assembly Parts Part Part Qty. Hardware Needed Hardware Qty. Tool Needed Tines 4 R Clip 2 Needle Nose Plier Wheel Assembly 1 Bolt M6 × 12 2 10mm Wrench or Socket Washer Ø6 2 N/A Wheels 2 Hubcaps 2 Lower Handle 1 Curved Head Bolt M8 × 45 4 N/...
Page 12 - ASSEMbLY; Tine installation or Reinstallation
100882 - CULTivATOR ASSEMbLY 12 ASSEMbLY Your cultivator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your cultivator, call our Technical Support Team at 1-87...
Page 13 - Slide a washer onto the axle on each side. Add the nut and; Handle Assembly; Attach the middle handle to the lower handle using the knob; Add fuel; Recommended mixing ratio; mix the fuel and oil in the engine fuel tank.
100882 - CULTivATOR ASSEMbLY 13 4. Slide a washer onto the axle on each side. Add the nut and hand tighten. 5. Snap hubcap to outside of each wheel. 6. Attach wheel assembly to main body, reverse steps 1-2. Handle Assembly 1. Attach the middle handle to the lower handle using the knob nuts, lock was...
Page 14 - Fueling the unit; OPERATiON; Starting and Stopping; To Start a Cold Engine:
100882 - CULTivATOR OPERATiON 14 Fueling the unit 1. Carefully pour the fuel mix into the cultivator’s fuel tank. 2. Only fill the fuel tank to 80% of the full capacity. 3. Fasten the fuel cap securely and wipe up any fuel spillage around the unit. Important: Always re-mix two-cycle fuel before fuel...
Page 15 - Press the throttle trigger when the engine starts. This will; To Start a Warm Engine:; Do not adjust the CHOKE lever. It should already be in the; To Stop the Engine; Only use fuel less than 60 days old.
100882 - CULTivATOR OPERATiON 15 5. Press the throttle trigger when the engine starts. This will automatically move the choke lever to the RUN position. Once the engine is running, release the throttle trigger. NOTiCE Manually adjusting or turning the choke lever to the CHOKE position during idle ...
Page 16 - Cultivating; Now You’re ready to Use Your Cultivator; For Deeper Cultivating:; Remove the obstruction while the engine is off.
100882 - CULTivATOR OPERATiON 16 Cultivating Now You’re ready to Use Your Cultivator If you’ve used a cultivator in the past you know that you walk behind a cultivator as the soil is churned. Your Champion cultivator may surprise you in the fact it works best if you pull it towards you. It tills bes...
Page 17 - MAiNTENANCE; Cleaning Air filter; Spark Plug; CAUTiON; Muffler
100882 - CULTivATOR MAiNTENANCE 17 MAiNTENANCE WARNiNG Never operate a damaged or defective cultivator. WARNiNG Improper maintenance will void your warranty. NOTiCE For Emission control devices and systems, read and understand your responsibilities for service as stated in the Emission Control...
Page 18 - intake Air Cooling vent; BEFORE USE; Inspect and clean fuel tank, air filter and fuel filter.; EVERY 25 HOURS; Clean cylinder fins and intake air cooling vent.; EVERY 50 HOURS
100882 - CULTivATOR MAiNTENANCE 18 intake Air Cooling vent – Never touch the cylinder, muffler, or spark plugs with your bare hands immediately after stopping the engine. The engine can become very hot when in operation, and doing so could result in severe burns. – When checking the machine before u...
Page 19 - STORAGE; Cultivator Storage; How to Prepare Your Cultivator for Restarting
100882 - CULTivATOR STORAGE 19 STORAGE Cultivator Storage Each fall — or before you store your cultivator for any long period — be sure to take these measures: 1. Do not store fuel in your cultivator for long periods of time. Even under ideal conditions, stored fuel containing ethanol can begin to s...
Page 20 - SPECifiCATiONS; Cultivator Specifications
100882 - CULTivATOR SPECifiCATiONS 20 SPECifiCATiONS Cultivator Specifications Start Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Recoil Gasoline/Oil Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
Page 21 - TROUbLESHOOTiNG; Flooded Engine Procedure:; Problem
100882 - CULTivATOR TROUbLESHOOTiNG 21 TROUbLESHOOTiNG If you follow the normal starting procedure, you should have no problem starting your cultivator. But, just in case you do have problems, here’s what to do: – Make sure the engine switch is in the “ON” position. If the switch was in the “STOP” p...
Page 22 - This warranty does not cover the following:; Normal Wear; Other Exclusions; This warranty excludes:; Contact Information; Address
WARRANTY* CHAMPION POWER EQUIPMENT2 YEAR LIMITED WARR ANT Y Warranty Qualifications To register your product for warranty and FREE lifetime call center technical support please visit: https://www.championpowerequipment.com/register To complete registration you will need to include a copy of the purc...
Page 23 - EMISSION CONTROL SYSTEM WARRANTY; YOUR WARRANTY RIGHTS AND OBLIGATIONS:
CHAMPION POWER EQUIPMENT, INC. (CPE) AND THE UNITED STATES ENVIRONMENTAL PROTECTION AGENCY (U.S. EPA) EMISSION CONTROL SYSTEM WARRANTY Your Champion Power Equipment (CPE) engine complies with U.S. EPA emissions regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: The U.S. EPA and CPE are pleased to ex...
Page 24 - GENERAL EMISSIONS WARRANTY COVERAGE; no charge to the owner at a CPE Authorized Service Outlet.
EMISSION CONTROL SYSTEM WARRANTY 1. APPLICABILITY: This section applies to Emissions Control Systems on small off-road engines or equipment that use small off-road engines subject to the emission standards in this Article. The warranty period begins on the date the new engine or equipment is deliver...
Page 25 - TO OBTAIN WARRANTY SERVICE:
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING: (using those portions of the list applicable to the engine) Systems covered by this warranty Parts Description Fuel Metering System Fuel regulator, Carburetor and internal parts Air Induction System Air cleaner, Intake manifold Ignition System Spark plug...
