Carrier 751 - Manuals

2 Models 750, 751, 754, 774, 794 To the Operator 050818 Section 2 To the Operator The freezer you have purchased has been carefully engineered and manufactured to give you dependable operation. The Taylor Company soft-serve models covered in this manual consist of the following: 750, 751, 754, 774, ...

4 Models 750, 751, 754, 774, 794 Operator Parts Identification Section 4 Operator Parts Identification Model 750 Item Description Part No. 1 Cover A.-Hopper X38458 2 Gasket-Hopper Cover 038375 3 Tube A.-Feed X29429-2 4 Panel-Rear 020891 5 Panel-Upper Side Right 042317 6 Pan-Drip 050766 7 Panel-Right...

10 Models 750, 751, 754, 774, 794 Operator Parts Identification Models 750 & 751 Single Spout Door and Beater Assembly ITEM DESCRIPTION PART NO. 1 HANDLE A.- DRAW X55096 1a DRAW HANDLE 028804 1b SCREW-ADJUST 055092 1c O-RING 1/4OD X .070W 015872 1d NUT-JAM 029639-BLK 2 NUT-STUD FLAT LONG 021508 ...

12 Models 750, 751, 754, 774, 794 Important: To the Operator Section 5 Important: To the Operator 750/751 754/774/794 ITEM DESCRIPTION 1 MIX LOW INDICATOR LIGHT 2 MIX REFRIGERATION KEY 3 STANDBY KEY 4 WASH KEY 5 AUTO KEY 6 POWER ON/OFF (TOGGLE) 7 RESET BUTTON Symbol Definitions To better communicate...

15 Models 750, 751, 754, 774, 794 Operating Procedures Section 6 Operating Procedures The Model 751 has been selected to illustrate the step-by-step operating procedures for all models contained in this manual. These models, for all practical purposes of operation, are the same. Each unit stores mix...

20 Models 750, 751, 754, 774, 794 Operating Procedures Install the air orifice into the hole in the top of the air tube (in the end without the small hole on the side). Figure 21 Step 11 Lay the air tube (with the air orifice installed) and the hopper gasket in the bottom of the mix hopper for sanit...

22 Models 750, 751, 754, 774, 794 Operating Procedures Step 9 Assemble the hopper gasket around the top edge of the mix hopper. Stand the air tube in the corner of the hopper. Figure 30 Repeat steps 1 through 9 for the other side of the freezer on Models 754, 774 and 794. Priming Step 1 With a pail ...

23 Models 750, 751, 754, 774, 794 Operating Procedures Step 7 Place the mix hopper cover in position over the mix hopper. Repeat steps 1 through 7 for the other side of the freezer on Models 754, 774, and 794. Closing Procedure To disassemble your unit, the following items will be needed: S Two clea...

24 Models 750, 751, 754, 774, 794 Operating Procedures Repeat steps 1 through 7 for the other side of the freezer on Models 754, 774 and 794. Disassembly MAKE SURE POWER SWITCH IS IN THE “OFF” POSITION! Failure to follow this instruction may result in severe personal injury from hazardous moving par...

25 Models 750, 751, 754, 774, 794 Important: Operator Checklist Section 7 Important: Operator Checklist During Cleaning and Sanitizing Cleaning and sanitizing schedules are governed by your State or local regulatory agencies and must be followed accordingly. The following check points should be stre...

26 Models 750, 751, 754, 774, 794 Important: Operator Checklist j 7. If your machine is equipped with an auxiliary refrigeration system, check the auxiliary condenser for accumulation of dirt and lint. Dirty condensers will reduce the refrigeration capacity of the mix hopper. Condensers must be clea...

27 Models 750, 751, 754, 774, 794 Troubleshooting Guide Section 8 Troubleshooting Guide PROBLEM PROBABLE CAUSE REMEDY PAGE REF. 1. No product is being dispensed with draw valve open and the machine in the AUTO mode. a. Freeze-up in mix inlet hole. a. Call service technician to adjust the mix hopper ...

30 Models 750, 751, 754, 774, 794 Parts Replacement Schedule Section 9 Parts Replacement Schedule PART DESCRIPTION EVERY 3 MONTHS EVERY 6 MONTHS ANNUALLY Drive Shaft Seal X Scraper Blade X Freezer Door Gasket X Front Bearing X Draw Valve O-Ring X Pivot Pin O-Ring X Prime Plug O-Ring X Air Tube O-Rin...

Section 10 Parts List 31 + Available Separately Models 750, 751, 754, 774, 794 Parts List H P 62 R efr ig er an t: 750 -- J61 10454, 751 -- J6080596, 754 -- J6080465, 774 -- J6092382, an d 794 -- J4094101/u p DE S CRI P T IO N PART NUM BE R 750 QTY . 751 QTY . 754 QTY . 774 QTY . 794 QTY . W ARR. CL...

+ Available Separately 40 Parts List Models 750, 751, 754, 774, 794 DE S CRI P T IO N PART S UP DA T E RE M ARKS W ARR. CL AS S 794 QTY . 774 QTY . 754 QTY . 751 QTY . 750 QTY . PART NUM BE R VAL VE A. -D R A W X 18303 1 1 3 3 3 103 J 7060000 (R E P L A C E S X 45380) 118 +O -R IN G 014402 2 2 6 6 6...