Campbell Hausfeld PW4070 - Manuals

Page 2 - Operating Instructions and Parts Manual; Frequently Asked Questions; DO NOT RETURN THE PRESSURE; Call Campbell Hausfeld

Operating Instructions and Parts Manual www.chpower.com Frequently Asked Questions How do I start my pressure washer? 1. Make sure you have gas and oil in the engine. The engine does not come with oil. 2. Turn the water on, then squeeze the trigger on the gun to make sure the water will flow smoothl...

Page 3 - Getting to Know Your Pressure Washer

3 Getting to Know Your Pressure Washer 1 Fuel Tank 2 Tip Holder with Spray Tips 3 Gun with Trigger 4 Engine switch - On/Off 5 Engine Oil Fill 6 Serial Number/Product Decal 7 Lance 8 Pressure Adjusting Knob 9 Injection Tube 10 Connection for High Pressure Hose 11 Inlet Connection for Garden Hose 12 F...

Page 4 - Safety Guidelines; NOTE; Important Safety Instructions; SAVE THESE INSTRUCTIONS; Safety and Warning Information

5. Know how to stop this product and bleed pressure quickly. Be thoroughlyfamiliar with the controls. 6. Stay alert – watch what you are doing. 7. Do not operate the product when fatigued or under the influence ofalcohol or drugs. 8. Keep operation area clear of all persons. 9. Do not overreach or s...

Page 6 - Operation; Surface Preparation; TRIGGER SAFETY LATCH

Figure 9 - Trigger unlocked Engaged Disengaged 6 Pre-Operation (Continued) 7. Install quick connect tip (See Figure 7). Operation Never run the unitdry. Be sure the water supply is completely turned onbefore operating the unit. 5. Trigger the gun until water sprays from the tip indicating that all a...

Page 7 - PRESSURE ADJUSTMENT; Initial High Pressure Rinse

7. Start the engine: Unlock the trigger safety latch on the gun. Grasp thestarter rope and brace one foot on thechassis. While squeezing the trigger onthe gun, pull the starter rope rapidlyand firmly. Continue holding the ropeas it returns. Repeat these steps untilthe engine starts. When pulling the...

Page 8 - Detergent Application

Operating Instructions and Parts Manual NOTE : Use only detergents formulated for pressure washers.Test detergent in aninconspicuous area before use. DETERGENTS The use of detergents can dramaticallyreduce cleaning time and assist in theremoval of difficult stains. Manydetergents are customized for ...

Page 9 - WINTERIZING INSTRUCTIONS; Maintenance; ENGINE OIL CHANGING INSTRUCTIONS

9 Operation (Continued) 5. Disconnect the spark plug wire and remove the spark plug. 6. Pour 1/2 oz. of engine oil into the spark plug hole. Never pull the starterrope on the engine when the spark plug is removed unlessthe spark plug hole is covered. Fuel vaporfrom the hole can ignite by a spark. 7....

Page 10 - Service Record

Engine Oil Type SAE 10W-30(See Honda’s Owner Manual) Engine Oil Capacity Honda GX160 20 fl. oz. Honda GX270 37 fl. oz. Honda GX390 37 fl. oz. Engine Fuel Capacity Honda GX160 3.3 US quarts (3.1 L) Honda GX270 5.6 US quarts (5.3 L) Honda GX390 6.4 US quarts (6.1 L) Pump Oil Type CAT pump oil Pump Oil...

Page 11 - Replacement Parts List; REPAIR MANUAL

11 www.chpower.com 1 Base Plate PM237600SJ PM237600SJ PM237600SJ 1 2 Pneumatic Wheel WA005620AV WA005620AV WA005620AV 2 3 Pushnut AL066300AV AL066300AV AL066300AV 2 4 5/16 in. -18 Nut PM031100AV PM031100AV PM031100AV 8 5 5/16 in. -18 Rounded square neck bolt MJ101206AV MJ101206AV MJ101206AV 8 6 Hand...

Page 12 - Troubleshooting Chart - Gasoline Powered Pressure Washers Only; Symptom

Operating Instructions and Parts Manual 12 www.chpower.com Troubleshooting Chart - Gasoline Powered Pressure Washers Only Symptom Possible Cause(s) Corrective Action(s) Engine will not start or ishard to start Engine misses or lackspower Low pressure and/or pumpruns rough Water leakage from underpum...

Page 13 - Notes

13 www.chpower.com PW2770, PW3270, and PW4070 Notes Troubleshooting Chart - Gasoline Powered Pressure Washers Only Pump noisy / pump runsrough Pressure washer will notspray detergent 1. Pump drawing in air/low water supply 2. Valves dirty or worn 3. Worn bearings 4. Water too hot 1. Not using soap t...

Page 14 - Limited Warranty

Operating Instructions and Parts Manual 14 www.chpower.com Limited Warranty 1. DURATION: From the date of purchase by the original purchaser as follows: Three Years2. WHO GIVES THIS WARRANTY (WARRANTOR): Campbell Hausfeld / Scott Fetzer Company, 100 Production Drive, Harrison, OH 45030, Telephone: 1...