Campbell Hausfeld HV2100 - Manuals

Page 2 - Description; DANGER; Unpacking; WARNING; NOTICE; CAUTION; Table of Contents

2 Operating Instructions and Parts Manual Description This product is a High Volume LowPressure (HVLP) Paint Sprayer, adurable, self-contained painting systemsuited for painting cabinets, furniture,machinery, equipment, walls, trim, andmany other surfaces. HVLP systemsoperate differently than those ...

Page 3 - HVLP Paint Sprayers; GROUNDING INSTRUCTIONS; Length of Cord; Extension Cord Requirements

HVLP Paint Sprayers 3 Operating Instructions and Parts Manual General SafetyInformation (Cont.) • Hazardous vapors: Paints,solvents, insecticides, andother materials may beharmful if inhaled, causingsevere nausea, fainting, orpoisoning. • Always wear a mask orrespirator and eye protectionwhen painti...

Page 4 - Figure 2 - Material flow knob positions and spray patterns

4 Operating Instructions and Parts Manual HVLP Paint Sprayers How Your HVLPSystem Works Your turbine system has threecomponents: the turbine unit, an airhose and a spray gun. The turbine unit,when connected to the correctelectrical power supply and poweredon, provides a continuous source ofclean, wa...

Page 5 - COATINGS; Turbine Performance; Table 2

5 Operating Instructions and Parts Manual Pre-Operation (Cont.) 4. Loosen the air cap locking ring one or two turns. This will feather thetop and bottom of the fan patternand slightly reduce the fan patternsize. COATINGS COATING PROPERTIES: Coatings are ablend of resins and additives to createa prod...

Page 6 - Operation; SPRAY PATTERNS; USING YOUR SPRAY GUN; Viscosity

6 Pre-Operation (Cont.) PREPARING TO SPRAY After some practice, you should beready to spray your coating of choiceon your work piece. (See the Operation section for more information on spray patterns, spraygun use, and other usage procedures).Good quality results with your HVLPsystem are a combinati...

Page 7 - SPRAYING TECHNIQUE; Figure 3 - Proper Spray Technique

7 HVLP Paint Sprayers Operating Instructions and Parts Manual www.chpower.com HV2100, HV2105 Operation (Cont.) 13. Pull the trigger. Notice the pattern has become smaller. (You cancontinue reducing the materialflow and move the spray gun evencloser to the surface and thepattern will keep getting sma...

Page 8 - UNPACKING

8 Operating Instructions and Parts Manual HVLP Paint Sprayers Operation (Cont.) USING PRESSURE POTS WITHTURBINE SYSTEMS (HV2105) When using a remote cup or pressurepot, it is necessary to introducecompressed air in order to pressurizethe remote pot and move the fluidfrom the pot to the tip/nozzle of...

Page 9 - PREPARING TO SPRAY

9 HVLP Paint Sprayers Operating Instructions and Parts Manual AdditionalInstructions for ModelHV2105 (Cont.) return valve, leaving the valveattached to the lower section ofthe tube. This will provide safestorage while using the spray gunwithout the cup in a productionmode. b. With a wrench, loosen t...

Page 10 - Maintenance

10 Operating Instructions and Parts Manual HVLP Paint Sprayers AdditionalInstructions for ModelHV2105 (3F485) (Cont.) NOTE: The following action should be done without the turbine running. 10. When your desired pot pressure has been set, pull the spray gun triggerback. The first time you are usingth...

Page 12 - Symptom; Troubleshooting Chart

12 Operating Instructions and Parts Manual HVLP Paint Sprayers www.chpower.com HV2100, HV2105 No paint comes out whentrigger is pulled Excessive overspray Coating on surface ofwork piece is not flat andlevel after drying (orangepeel effect) When spray gun isconnected to turbine andturbine is on, air...

Page 13 - Turbine Repair Parts; and Fluid Feed System

13 Operating Instructions and Parts Manual www.chpower.com HV2100, HV2105 Turbine Repair Parts 2-1/2 Gallon (10L) Cart and Fluid Feed System Part No. HV210510AV Filter Assembly Part No. CH4098 5’ Whip Hose Part No. HV0125 25’ Air Hose Part No. HV0126 For Replacement Parts, Call 1-800-626-4401 Please...

Page 14 - Spray Gun with Quick Release Cup

14 www.chpower.com Operating Instructions and Parts Manual HV2100, HV2105 Spray Gun with Quick Release Cup

Page 15 - Parts List for Spray Gun with Quick Release Cup

15 www.chpower.com Operating Instructions and Parts Manual HV2100, HV2105 Ref. No. Description Part Number Qty. 1 Air cap ring A.5200 1 2 Air cap #2 HV104505AV 1 Air cap #3 A.5297 1 3 Air distributor plate (stainless) HV104511AV 1 4 Air distributor spring (stainless) HV104512AV 1 5 Not applicable 6 ...

Page 17 - Parts List for Cart Assembly, For Model No. HV2105 Only

17 www.chpower.com Operating Instructions and Parts Manual HV2100, HV2105 Ref. No. Description Part Number Qty. 1 Cart base plate paint blue A.4554 1 2 Cart axle (zinc plated) A.4555 1 3 Wheel spacer (6061 alu.) A.4556 2 4 10” x 1-3/4” wheel A.4558 2 5 1/2” Axle cap A.4374 2 6 Frame tube (chrome) A....

Page 19 - Parts List for Fluid Tank Assembly, For Model No. HV2105 Only

19 www.chpower.com Operating Instructions and Parts Manual HV2100, HV2105 Ref. No. Description Part Number Qty. 1 Fluid tank A.4901 1 2 Lid assembly A.4902 1 3 Handle A.4903 1 4 Gasket A.4904 1 5 Material pickup tube A.4905 1 6 Material filter housing A.4906 1 7 Filter base A.4907 1 8 Material filte...

Page 20 - Limited Warranty

20 Operating Instructions and Parts Manual www.chpower.com HV2100, HV2105 Limited Warranty 1. DURATION: From the date of purchase by the original purchaser as follows: Standard Duty Paint Application Systems and all Paint Application Accessories - 1 year, Serious Duty Paint Application Systems - 3 y...