Broilmaster SBB 2804 - Manuals

SBB00104-1-1107 Page 7 PARTS LIST INDEX NO. PART NUMBER DESCRIPTION 1 SBB00014 THERMOMETER 2 SBB00108 LID 3 SBB00013 NUT AND LID BOLT 4 SBB00078 WARMING RACK 5 SBB00064 ROTISSERIE MOTOR 6 SBB00065 ROTISSERIE MOTOR BRACKET 7 SBB00067 ROTISSERIE ROD 8 SBB00068 ROTISSERIE FORKS 9 SBB00069 ROTISSERIE RO...

SBB00104-1-1107 Page 8 GRILL ASSEMBLY Before You Begin This grill requires some assembly and installation. Follow all instructions.If you purchased an accessory with your Superb by Broilmaster ® Gas Grill, follow the instructions provided with the accessory for assembly and installation. If an instr...

SBB00104-1-1107 Page 9 Surround Kit Location Built-In Kits are designed for outdoor use ONLY. This Built-In Kit is designed for use with SBB2804 Broilmaster ® gas grills and cannot be used with any other grill or in any other capacity.Never install or operate your Built-In Kit in any building, garag...

SBB00104-1-1107 Page 10 Enclosure must be construction from non-combustible material. If tile is used on the top surface of your enclosure, it may be necessary to enlarge openings at the top edges to allow the frame pieces of the SBB and BSA to mount flush against the enclosure. Screws for enclosure ...

SBB00104-1-1107 Page 12 8. Remove ignitor button, insert AA battery (provided) positive side facing out, replace ignitor button. See Figure 7. 4. Attach grill head to surround from inside of the grill with four (4) lock washers, and 1/2” screws (provided). See Figure 5. 5. Place flame tamers over bur...

SBB00104-1-1107 Page 13 ROTISSERIE INSTALLATION The Infrared burner (Rotisserie burner) is for rotisserie cooking only. Warning: Never use the main burners while using the Infrared Back Burner, as this could result in igniting the drip- pings, or overheating your grill. Remove warming rack and cooki...

SBB00104-1-1107 Page 14 1. Turn the burner control knobs clockwise to the OFF position. 2. Turn ON gas at the source. 3. Open the grill lid. 4. Locate the Ignitor Rod, which is permanently attached to the inside of the right surround side. 5. Insert an unlit match into the coiled end of the ignitor ...

SBB00104-1-1107 Page 15 ROTISSERIE OPERATION Using the IgnitorCaution: If burner fails to light after 5 seconds, turn the burner OFF for 5 minutes, to allow the gas to clear, then try again.Attention: You must use the control knob that is second from the left side of grill to ignite the rotisserie.1...

SBB00104-1-1107 Page 16 PROPANE GAS GRILLS Grill Location When choosing the ideal location for your Superb by Broilmaster ® Gas Grill, remember this grill is designed for outdoor use ONLY.You should never install or operate your grill in any building, garage, or other enclosed area.For your safety, ...

SBB00104-1-1107 Page 18 GAS CONVERSION TO LIQUID PROPANE GAS A conversion kit to liquid propane (LP) gas is included with your grill. 1. Remove cooking grids and flame tamer from grill. 2. Use allen wrench supplied in conversion kit to remove control knobs. 3. Remove control panel (4 Phillips screws)...

SBB00104-1-1107 Page 19 OPERATION Checking for Gas Leaks Check for gas leaks every time you connect your Superb by Broilmaster ® propane gas grill to a Propane gas cylinder, when a connected cylinder has not been used recently, or when either a natural or propane grill is being used for the first tim...

SBB00104-1-1107 Page 21 MAINTENANCE Cleaning the Grill Caution: To prevent injury, do not clean a hot grill.Note: Do not use a commercial cleaner on the cooking grids. Do not brush grids while they are hot. Do not scrape grids. For baked on residue use a BRASS (NOT STEEL) brush on the cooking grids ...

SBB00104-1-1107 Page 22 TROUBLESHOOTING Although the manufacturer has attempted to ensure that your grill will operate properly and satisfactorily, sometimes problems do arise. The following troubleshooting guide lists several possible problems and their probable cause and solution. Problem Cause So...

SBB00104-1-1107 Page 23 WARRANTY TERMS Limited Lifetime Warranty • SBB2804 Stainless Steel Grill Lid, Body, and Cooking grids, Stainless Steel Built-In Sur- round 5 Years Against Rust-Through • Stainless steel burners • Infrared rotisserie burners • Stainless steel warming rack • Stainless steel flam...

SBB00104-1-1107 Page 24 BROILMASTER ® A Division of Empire Comfort Systems, Inc. 918 Freeburg Ave. Belleville, Illinois 62220 Phone: 1-800-851-3153 FAX: 1-800-443-8648 V ISIT OUR WEB SITE AT WWW . broilmaster.com T HE M OST D URABLE G RILL K NOWN T O M AN