Bard W30A1 - Manuals

Bard W30A1 – Manual in PDF format online.

Manuals:

Manual

Manual Bard W30A1

Summary

Page 2 - Contents

Manual 2100-508F Page 2 of 25 Contents Figures Figure 1 Fresh Air Damper Assembly ................... 5 Figure 2 Unit Dimensions ...................................... 7 Figure 3A Mounting Instructions .............................. 8Figure 3B Mounting Instructions - W17 – 36 .............. 9 Figure...

Page 3 - GETTING OTHER INFORMATION AND PUBLICATIONS

Manual 2100-508FPage 3 of 25 GETTING OTHER INFORMATION AND PUBLICATIONS These publications can help you install the airconditioner or heat pump. You can usually find these atyour local library or purchase them directly from thepublisher. Be sure to consult current edition of eachstandard. National E...

Page 4 - WALL MOUNT GENERAL INFORMATION; AIR CONDITIONER WALL MOUNT MODEL NOMENCLATURE; SHIPPING DAMAGE

Manual 2100-508FPage 4 of 25 WALL MOUNT GENERAL INFORMATION AIR CONDITIONER WALL MOUNT MODEL NOMENCLATURE W 42 A 1 – A 10 X X X X X A NOTE: Vent options X, B and M are without exhaust capability. May require separate field supplied barometric relief in building. SHIPPING DAMAGE Upon receipt of equip...

Page 5 - DUCT WORK; Refer to Maximum ESP of operation Electric Heat Table 6.; NOTE: If no return air duct is used, applicable installation; FILTERS; FIGURE 1

Manual 2100-508FPage 5 of 25 DUCT WORK All duct work, supply and return, must be properly sizedfor the design airflow requirement of the equipment. AirConditioning Contractors of America (ACCA) is anexcellent guide to proper sizing. All duct work or portionsthereof not in the conditioned space shoul...

Page 6 - INSTALLATION INSTRUCTIONS; WARNING; WALL MOUNTING INFORMATION

Manual 2100-508FPage 6 of 25 s s e c c A e c i v r e S r o f d e r i u q e R s e c n a r a e l C w o l f r i A r e s n e d n o C e t a u q e d A d n a S L E D O M E D I S T F E L E D I S T H G I R A 6 3 W , A 0 3 W , A 4 2 W , A 8 1 W , A 7 1 W " 5 1 " 0 2 L 6 3 W , L 0 3 W , L 4 2 W , L 8 1...

Page 7 - FIGURE 2

Manual 2100-508FPage 7 of 25 I A C K 2.13 H J 2.63 9.06 P M L O E .44 W 5.75 F G R S S S S S T D Return Air Opening MIS-2488 B Drain Inlet Air Air Outlet Front View Side View Cond. 1 Back View Condenser Bracket Installation Bottom (Built In) Brackets Mounting Side Wall Location Shipping Flashing Ent...

Page 11 - minimum

Manual 2100-508FPage 11 of 25 FIGURE 4 ELECTRIC HEAT CLEARANCE W30A1, W30L1, W36A1, W36L1, W42A1, W42L1, W48A1, W48L1, W60A1, W60L1, W70A1, W70L1 WARNING A minimum of 1/4 inch clearance must be maintained between the supply air duct and combustible materials. This is requiredfor the first 3 feet of ...

Page 14 - WIRING – MAIN POWER; must be; WIRING – LOW VOLTAGE WIRING; TAP; NOTE: The voltage should be measured at the field power

Manual 2100-508FPage 14 of 25 WIRING – MAIN POWER Refer to the unit rating plate for wire sizing informationand maximum fuse or “HACR” type circuit breakersize. Each outdoor unit is marked with a “MinimumCircuit Ampacity”. This means that the field wiringused must be sized to carry that amount of cu...

Page 15 - START UP; TOPPING OFF SYSTEM CHARGE

Manual 2100-508FPage 15 of 25 START UP THESE UNITS REQUIRE R-410AREFRIGERANT AND POLYOLESTER OIL. GENERAL: 1. Use separate service equipment to avoid cross contamination of oil and refrigerants. 2. Use recovery equipment rated for R-410A refrigerant. 3. Use manifold gauges rated for R-410A (800 psi/...

Page 16 - proper rotation; NOTE: If compressor is allowed to run in reverse rotation; PHASE MONITOR; Do not reverse any of the unit factory; CONDENSER FAN OPERATION

Manual 2100-508FPage 16 of 25 START UP (Continued) IMPORTANT INSTALLER NOTE For improved start up performance wash the indoor coilwith a dish washing detergent. HIGH PRESSURE SWITCH All W**A/W**L wall mounted air conditioner seriesmodels are supplied with a remote reset for the high andlow pressure ...

Page 17 - SEQUENCE OF OPERATION; COOLING; COMPRESSOR CONTROL MODULE; Adjustable Delay On Make And Break Timer; delay on make; High Pressure Switch and Lockout Sequence; soft lockout; Alarm Relay Output; NOTE: Both high and low pressure switch controls are; ADJUSTMENTS; Typical Settings for Dual Unit Installation:; PRESSURE SERVICE PORTS

Manual 2100-508FPage 17 of 25 SEQUENCE OF OPERATION COOLING – Circuit R-Y makes at thermostat pulling in compressor contactor, starting the compressor andoutdoor motor. The G (indoor motor) circuit isautomatically completed on any call for coolingoperation or can be energized by manual fan switch on...

Page 18 - TROUBLESHOOTING; FIGURE 8; REFRIGERANT CHARGE; Remove the screws holding both grilles, one on each; FAN BLADE SETTING DIMENSIONS

Manual 2100-508FPage 18 of 25 TROUBLESHOOTING FIGURE 8 FAN BLADE SETTING MIS-1724 TABLE 1 FAN BLADE DIMENSION R-410A REFRIGERANT CHARGE This unit was charged at the factory with the quantity ofrefrigerant listed on the serial plate. AHRI capacity andefficiency ratings were determined by testing with...

Page 20 - TABLE 3; Electrical Specifications — W**A Series

Manual 2100-508FPage 20 of 25 TABLE 3 1 Maximum size of the time delay fuse or HACR type circuit breaker for protection of field wiring conductors. 2 Based on 75C copper wire. All wiring must conform to the National Electrical Code and all local codes. 3 These “Minimum Circuit Ampacity” values are t...

Page 21 - TABLE 4; Electrical Specifications — W**L Series

Manual 2100-508FPage 21 of 25 TABLE 4 1 Maximum size of the time delay fuse or HACR type circuit breaker for protection of field wiring conductors. 2 Based on 75C copper wire. All wiring must conform to the National Electrical Code and all local codes. 3 These “Minimum Circuit Ampacity” values are t...

Page 24 - HEATER KITS

Manual 2100-508FPage 24 of 25 W17/18A1-A W24A1-A W24A1-B W24A1-C W30A1-A W30A1-B W30A1-C W36A1-A W36A1-B W36A1-C W42A1-A W42A1-B W42A1-C W48A1-A W48A1-B W48A1-C W60A1-A W60A1-B W60A1-C W70A1-A W70A1-B W70A1-C TABLE 9 OPTIONAL ACCESSORIES r e b m u N t r a P 5 0 A - 2 0 A W H E X X 8 0 A - A 2 0 W H ...

Page 25 - VENT & CONTROL OPTIONS

Manual 2100-508FPage 25 of 25 TABLE 10 VENT & CONTROL OPTIONS W17, W18, W24 W30, W36 W42, W48, W60, W70 r e b m u N t r a P n o i t p i r c s e D 4 1 - C M C T D O X X X 5 1 - C M C ) e s a h P - 1 V 0 3 2 ( t i K t r a t S X X X 3 2 - C M C C D D X X 4 2 - C M C C D D X 8 2 - C M C C A L X X X ...