Ariens GARDEN TRACTORS 931013 S-14G- Manuals

Ariens GARDEN TRACTORS 931013 S-14G– User Manual in PDF format online.

Manuals:

User Manual

User Manual Ariens GARDEN TRACTORS 931013 S-14G

Summary

Page 2 - WARNING; HIFT; ©CAUTION; INSTRUCTIONS FOR SAFE OPERATION

DECALS FOR MODELS 931013 & 931014 GEAR TRACTOR WARNING •BRAKES Will NOT STOP TRACTOlf > <;UNLESS CLUTCH PEDAL IS DEPRESSED” ^3 r " s HIFT selector is in NEUTRAL.Xji^ LIFT SELEQOR REAR LIFT PARKING BRAKE UEPRL'SS BRAKE PEDAL !HEN ENGAGE PARKING/'N^ BRAKt lOCK />G j ‘FRONT AND CENTER ...

Page 3 - warning; BE AWARE OF SAFETY DECALS

DECALS FOR MODELS 931013 & 931014 GEAR TRACTOR A warning ] I Grasp handle, not chain. 78282 S-10 G ONLY S-10G78388 P , I ii F R T - ( , T R L I G H T S I M P L P O W E R DASH PANEL - 78341 % R T i M G P R O C E D U R E ^CAUTION RELEASE LIFT ASSIST SPRING BEFORE DISCONNECTING I I ATTACHMENT FROM ...

Page 4 - CONTROLS

CONTROLS Implement Power Control Switch (Figure 1). Pull the switch out (ON) to engage the electromagnetic clutch to drive the mower and front mount ed attachments. N O TE : This sw itchQ m ust be pushed in (O FF) to disengage the drive before the engine w ill start or to allow engine to keep runn...

Page 5 - OPERATION

OPERATION To run the tractor in REVERSE, shift to reverse gear. PRE-STARTING INSPECTION Prior to starting the engine for each day's operation, the following checks and services should be performed; a. Check oil in engine crankcase. Add oil as required to maintain proper level. b. Check fuel supply. ...

Page 6 - LUBRICATION

STOPPING THE TRACTOR To stop the tractor, depress the clutch pedal @ and depress the brake pedal (ñ) . Then place the shift lever in the "Neutral" position and set the parking brake. Figure 4. STOPPING THE ENGINE Always use the following procedure to stop the engine: 1. Move the gear shift l...

Page 8 - MAINTENANCE

GREASE STEERING SYSTEM Under normal conditions the steering system should be lubricated every J50 hours of operation or quarterly whichever occurs first. The following list of grease fittings are identified in Figure 12. Wipe each fitting clean before and after lubrication! Use a good grade of gener...

Page 9 - ADJUSTMENTS

The engine is air cooled. Air must circulate freely around the engine from the air intake screen shown in Figure 15 and over the cooling fins in the cylinder head and block to prevent overheating. Every 50 hours of operation or quarterly check the air intake screen. Wipe away any dirt or debris whic...

Page 13 - STORAGE

FIGURE 25 STORAGE PREPARATION FOR STORAGE 1. Remove all oil, grease and dirt from engine and trans mission. 2. Clean the tractor exterior and tires thoroughly, removing all mud, dirt and grease. 3. Touch up all unpainted and exposed areas with paint to prevent rust. 4. Change engine oil. 5. Disconn...

Page 15 - STEERING GEAR ASSEMBLY

FRAME. STEERING, FRONT WHEEL GEAR MODELS 931013 & 931014 REF NO. PART N0. DESCRIPTION NO REQ'D REF NO. P art NO. DESCRIPTION NO REQ'D 1 031084 STEERING WHEEL 1 34 031568 WASHER, SPECIAL 2 2 059004 CAPSCREW, HH,3/8 - 16x 1 2 35 059154 CAPSCREW, 3/8 X 6 X 3/4 Grade 5 2 3 631131 STEERING GEAR ASS'Y...

Page 20 - HYDRAULIC LIFT AND FRONT ROCK SHAFT

HYDRAULIC LIFT AND FRONT ROCK SHAFT GEAR MODEL 931013 ONLY - 2 0 -

Page 21 - HYDRAULIC LIFT AND FROISIT ROCK SHAFT

HYDRAULIC LIFT AND FROISIT ROCK SHAFT GEAR MODEL 931013 ONLY REF N0, PART NO. DESCRIPTION NO REQ'D. REFNO. PART NO. DESCRIPTION NO REQ'D. 1 531067 CYLINDER ASS'Y (includes adapters) 1 41 031787 CIRCULATION COVER 1 • 2 031170 VALVE 1 42 030009 FILLER COVER 1 3 031779 HOSE, 20" Long, Pump to Valve...

Page 22 - REAR BRAKE & CLUTCH ASSEMBLY

REAR BRAKE & CLUTCH ASSEMBLY GEAR MODELS 931011&931012

Page 23 - REAR BRAKE & CLUTCH ASSEMBLY PARTS

REAR BRAKE & CLUTCH ASSEMBLY PARTS GEAR MODELS 931013 & 931014 REF N0. PART N0 DESCRIPTION NO REQ'D 931014 931013 REF NO. PART NO DESCRIPTION NO REQ'D 931014 931013 1 031679 TORQUE, Spider 2 2 33 062013 BOLT, Carriage 3/8" x 1" 4 4 2 031678 DUST SHIELD 2 2 34 067006 PIN, Cotter 3/16&...

Page 24 - MAIN DRIVE

Page 26 - MODEL 931014 MANUAL LIFT & LINKAGE ASSEMBLY PARTS

MODEL 931014 MANUAL LIFT & LINKAGE ASSEMBLY PARTS REAR LEFT BRAKE PEDAL

Page 27 - MODEL 931014 MANUAL LIFT & LINKAGE ASSEMBLY PARTS LIST

MODEL 931014 MANUAL LIFT & LINKAGE ASSEMBLY PARTS LIST REF NO PART NO DESCRIPTION NO REQ'D REF NO PART NO DESCRIPTION NO REQ'D 1 031759 LIFT HANDLE 1 26 067004 COTTER PIN 1 2 031760 PLUNGER 1 27 062005 CARRIAGE BOLT 3/8 x 2-1/4 4 3 058034 PIN, Roll 1/8" X 3/4" 1 28 031764 QUADRANT 1 4 06...

Page 29 - REAR ROCK SHAFT

REAR ROCK SHAFT REF NO. PART N0. DESCRIPTION NO. REQ'D. 1 031534 ARM 2 2 031497 SHAFT 1 3 055085 BEARING, Rockshaft 4 4 031693 WASHER, 1-1/32 Hex 1 5 031498 LATCH 1 6 083105 SPRING 2 7 031499 LATCH ROD 1 8 075052 KNOB 1 9 067022 HAIRPIN COTTER 4 10 031012 PIN 2 11 031008 PIN, Clevis 1 12 031007 BRAC...

Page 30 - CENTER ROCK SHAFT

CENTER ROCK SHAFT REF NO. PART NO. DESCRIPTION NO. REQ'D. 1 031790 CENTER ROCK SHAFT 1 2 029011 BEARING BLOCK 4 3 064115 SHIM, .005 Thick 4 4 031811 R.H. ROCKSHAFT LEVER 1 5 058063 PIN GROOVE, 1/4x2 1 6 083167 SPRING, Torsion 1 7 031809 SPRING HANDLE 1 8 011120 BOLT, Shoulder 1 9 062005 BOLT, Carria...

Page 31 - FRONT PTO AND ELECTRICAL CLUTCH

FRONT PTO AND ELECTRICAL CLUTCH GEAR MODELS 931013 & 931014 REF N0. PART N0. DESCRIPTION NO REQ'D REF NO. PART NO. DESCRIPTION NO REQ'D 1 531013 PTO HOUSING W/Needle Bearing 1 17 066027 KEY, Square, 1/4 x 5/8" 1 2 031183 SHAFT 1 18 059023 CAPSCREW, HH, 3/8 X 3/4 2 3 054102 NEEDLE BEARING 1 1...

Page 32 - DASH, CONTROLS AND ELECTRICAL

DASH, CONTROLS AND ELECTRICAL ALL MODELS REF NO. PART NO. DESCRIPTION NO. REQ'D REF NO. PART NO. DESCRIPTION NO. REQ'O 1 531058 DASH W/Decal 1 30 025172 SWITCH 1 2 031150 SWITCH, Clutch 1 31 065032 NUT, Hex, 1/4" 8 3 031151 SWITCH, Lights 1 32 063029 LOCKWASHER, Internal Tooth, 9/16" j 1 4 0...

Page 33 - ELECTRICAL WIRING DIAGRAM

ELECTRICAL WIRING DIAGRAM ALL MODELS EQUIPPED WITH INTERLOCK MODULE 531074 REF N0. PART N0. DESCRIPTION NO. REQ'D REF NO. PART NO. NO. DESCRIPTION REQ'D 1 031150 SWITCH, Clutch 1 25 031149 HEAD LIGHT 2 2 031151 SWITCH, Lights 1 26 031722 WIRE HARNESS, 2 Wire 1 3 031152 SWITCH, Ignition 1 27 031147 W...

Page 34 - GEAR MODELS

ELECTRICAL WIRING DIAGRAM GEAR MODELS EQUIPPED WITH INTERLOCK MODULE 31976 OR 531099 REF NO. PART NO. DESCRIPTION 1 031150 SWITCH, Clutch 2 031151 SWITCH, Lights 3 031152 SWITCH, Ignition 5 031085 BATTERY, 12 Volt 6 031111 CABLE ASS'Y, Solenoid to Starter 7 031720 SOLENOID STARTER SWITCH 8 031117 AM...

Page 35 - ARIENS; GARDEN TRACTOR

ARIENS GARDEN TRACTOR DEALERASSEMBLY AND PRE-SERVICE INSTRUCTIONS BATTERY CABLE Figure 1A STEERING WHEEL Install steering wheel on the column as shown in Figure 1 A. Secure with nut provided. Place the plastic cap firmly in the steering wheel hub. SERVICE BATTERY Remove the battery from the tractor....

Page 36 - DELIVERY

CHECK TRANSAXLE OIL LEVEL The oil level in the rear end should be checked every 25 hours of operation or monthly. A C A U TIO N .P roper oil level Is essential for protection against severe dam age to the transaxle. Use the following procedure to check the transaxle oil level: 1. Drive tractor onto ...