Page 2 - I m p o r ta n t I n f o r m a t i o n; Important Notices for Servicers and Consumers; W A RN IN G; Service Support Center; DANGER; W A R N IN G; C A UTION
2 16022149 ©2005 Maytag Services I m p o r ta n t I n f o r m a t i o n Important Notices for Servicers and Consumers Maytag will not be responsible for personal injury or property damage from improper service procedures. Pride andworkmanship go into every product to provide our customers with quali...
Page 3 - Table of Contents; General Information
©2005 Maytag Services 16022149 3 3 Table of Contents Important Information .................................................... 2Important Safety Information ......................................... 4 Wiring ..................................................................... 8Earthing Instruction...
Page 4 - Important Safety Information
4 16022149 ©2005 Maytag Services Important Safety Information
Page 7 - CAUTION
©2005 Maytag Services 16022149 7 CAUTION ! Read the following information to avoid possibleexposure to microwave radiation: The basic design of the Amana and Menumastermicrowave ovens make it an inherently safe device toboth user and servicer. However, there are someprecautions which should be follo...
Page 8 - Earthing Instructions; WARNING; Servicing of Earthed Products; WARNING; Wiring
8 16022149 ©2005 Maytag Services WARNING ! To avoid risk of electrical shock, personal injury ordeath, make sure these earthing instructions arefollowed. Earthing Instructions WARNING ! Do not remove earthing prong when installing earthedappliance in a home or business that does not havethree wire e...
Page 9 - Unpacking Oven; Do not attempt to use oven if damaged.; Oven Placement; MUST; Earth
General Information ©2005 Maytag Services 16022149 9 Unpacking Oven • Inspect oven for damage such as dents in door or inside oven cavity. • Report any dents or breakage to source of purchase immediately. • Do not attempt to use oven if damaged. • Remove all materials from oven interior.• If oven ha...
Page 10 - Microwave Oven Description; Equipment requires a; Equipment requires a
General Information 10 16022149 ©2005 Maytag Services Microwave Oven Description A—Door HandleB—Spatter ShieldC—Top Control panelD—DisplayE—Side Control PanelF—Air Filter 230 V / 13 AMP Receptacle Plug Equipment requires a 230 VAC, 50 Hz, 13 amp power supply Receptacle Plug 230 V / 16 AMP Equipment ...
Page 11 - Troubleshooting; POWER UP CONDITION NORMAL; Power Up; YES
Troubleshooting ©2005 Maytag Services 16022149 11 Plug oven into power source with oven door closed. POWER UP CONDITION NORMAL Proceed to DISPLAY DIAGNOSTICS. 1. No line voltage. 2. Inoperative power cord.3. Inoperative fuse.4. Inoperative display board.5. Inoperative H.V. board.6. Broken or loose w...
Page 12 - Standby Condition
Troubleshooting 12 16022149 ©2005 Maytag Services Blower motor operates? Inoperative blower motor.Inoperative auto-transformer. Broken or improper wire connections. 1.2.3. "Standby Condition" normal - proceed to "Cook Condition". Yes Yes Open oven door. Oven light is on? Antenna moto...
Page 13 - NOTE; Cook Condition
Troubleshooting ©2005 Maytag Services 16022149 13 Display starts counting down. Yes Place cup of water inoven and close oven door. Open oven door, water is properly heated? Beep not programmed into oven.Pad not programmed. Display indicates 00:00 and beeps rapidly. Inoperative touch panel. 1.2. 3. N...
Page 14 - Component Testing Procedures; Refer to Technical Sheets for specific model information.
Component Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. 16022149 ©2005 Maytag Services 14 Refer to Technical Sheets for specific model information. Illustrati...
Page 18 - Relay Test; Three Magnetron Models
Component Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. 16022149 ©2005 Maytag Services 18 Refer to Technical Sheets for specific model information. NOTE: For ...
Page 20 - Two Magnetron Models
Component Testing Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. 16022149 ©2005 Maytag Services 20 Two Magnetron Models # 1 # 1 # 1 # 1 # 3 # 3 # 3 # 3 H.V. System # 1...
Page 21 - Power Testing Procedure; Test equipment required:; Procedure; Minimum Temperature Rise at Thirty -Three (33) Seconds Run Time
Power Testing Procedure ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. ©2005 Maytag Services 16022149 21 All Amana and Menumaster microwave oven power outputs are rated using the...
Page 22 - Display Diagnostics; Error Codes
Display Diagnostics ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. 16022149 ©2005 Maytag Services 22 CAUTION ! 1. All repairs as described in this troubleshooting section are to ...
Page 23 - Service Test; To Enter Service Test Mode, oven door must be closed.; NOTE: Pads will not beep when accessing Service Test Mode.
Service Test ©2005 Maytag Services 16022149 23 PREHEAT STANDBY C LEVEL READY PREHEAT STANDBY C LEVEL READY PREHEAT STANDBY C LEVEL READY 1 2 3 1 3 5 7 9 To Enter Service Test Mode, oven door must be closed. NOTE: Unit must be in OFF condition or INITIAL power up mode. Toggles Magnetron 2 (Top Front)...
Page 25 - Service Information; Proper Handling of Magnetron Tubes; Magnetron Failure Modes; Shorted; Low Power; Physical Damage
Service Information ! WARNING To avoid risk of electrical shock, personal injury, or death, disconnect power to oven and discharge capacitor before servicing, unless testing requires power. ©2005 Maytag Services 16022149 25 Proper Handling of Magnetron Tubes CAUTION ! A magnetron tube, like a radio ...
Page 27 - Microwave Leakage Testing; Equipment
Microwave Leakage Testing ! WARNING To avoid risk of electrical shock, personal injury, or death, disconnect power to oven and discharge capacitor before servicing, unless testing requires power. ©2005 Maytag Services 16022149 27 WARNING ! Check for radiation leakage after servicing. Should the leak...
Page 28 - D i s a s s e m b l y; Inner Door Ring Assembly; Hinge; Pointed tip; Door
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING 28 16022149 ©2005 Maytag Services Inner Door Ring Assembly 1. Remove latch handle.2. Remove outer door assembl...
Page 30 - Top Rear Magnetron; interlock switch; Display Module
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING 30 16022149 ©2005 Maytag Services Top Rear Magnetron 1. See “Component Location” Figure 2, for location.2. Rem...
Page 31 - must; Fan Blade
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING ©2005 Maytag Services 16022149 31 Magnetron Cutout (TCO) 1. See “Component Location” Figure 2, for location.2....
Page 32 - Top Antennas; Bottom Antenna
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING 32 16022149 ©2005 Maytag Services Top Antennas 1. See “Component Location” Figure 1, for location.2. Remove ou...
Page 33 - If fuse needs replaced, interlock assembly must; Tools Needed; authorized distributor or servicer)
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING ©2005 Maytag Services 16022149 33 To remove bulb,turn in directionshown. Fuse 1. See “Component Location” Figu...
Page 34 - Component Location; Figure 1
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING 34 16022149 ©2005 Maytag Services Component Location Figure 1 Touch Panel (Top) Touch Panel (Side) Display Mod...
Page 35 - Figure 2
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING ©2005 Maytag Services 16022149 35 Figure 2 Filter Magnetrons Magnetron TCO's Splatter Shield OvenTray BottomEx...
Page 36 - Figure 3
D i s a s s e m b l y To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitorsbefore following any disassembly procedure. ! WARNING 36 16022149 ©2005 Maytag Services Figure 3 Auto Transformer Fan Blade Capacitor Transformer High Voltage Board...