Amana AK2H30, AK2H36E2, AK2HW2 - Manuals

Introduction RS2420002 Rev. 5 5 Amana Cooking Products Nomenclature Brand Product Group Product Type Features Color A - AmanaC - Caloric or Canadian if followed by A (Amana)N - InternationalZ - Canadian G - Gas Wall ovenR - Electric WallovenK - CooktopCO - Convection Wall Oven O - Wall Oven DG1- Dow...

Important Information RS2420002 Rev. 5 6 WARNING ! General 1. The cooktop must be installed and/or repaired by an authorized installer or servicer. 2. Never use the cooktop for warming or heating the room. 3. Do not store items on the cooktop. Items stored on the cooktop can become too hot and melt....

Installation Instructions RS2420002 Rev. 5 7 CAUTION ! To avoid risk of property damage afterunpacking the cooktop, handle it carefully anddo not slide it across countertops. Installation Options Some models may be installed with the glass top eitherresting on the counter or recessed into the counte...

Installation Instructions RS2420002 Rev. 5 8 WARNING ! To avoid risk of serious burns or other personalinjury by reaching over heated surfaceelements, avoid locating cabinet storage abovesurface units. If cabinet storage above the unitis to be provided, reduce risk by installing arange hood that pro...

Installation Instructions RS2420002 Rev. 5 9 6. Apply foam tape to the underside of the cooktop glass and flush with edge of the cooktop frame. Thefoam tape prevents sealant from seeping betweenthe countertop and the underside of the cooktop.Service problems may arise if foam tape is notapplied corr...

Operating Instructions RS2420002 Rev. 5 10 Using the Cooktop • Use Proper Pan Size Use cooking utensils with flat bottoms largeenough to cover the flame. Correct-sized utensilsimprove cooking efficiency and promotes safety.Undersized utensils expose clothing and spilloversto direct flame. • Never Le...

Operating Instructions RS2420002 Rev. 5 11 AKH, AK2H, CAK2H, and CAKH UnitDescription AKH and CAKH units feature one halogen element.AK2H units feature two Haloring  elements. Halogen elements reach cooking temperature quickly and providean even heat. Both features improve cookingperformance. Halog...

Operating Instructions RS2420002 Rev. 5 12 Operating Halogen HeaterOperate the halogen heater element by pushing in thecontrol knob and turning to desired setting. The controlsetting cycles the element on and off to maintain heat.Turn control knob to OFF position when finished. Operating 10 − Positi...

Troubleshooting Procedures RS2420002 Rev. 5 13 Cleaning Glass/ Ceramic Cooktop Problem Cause To Prevent To Remove Brown streaks and spots. Cleaning with a sponge ordishcloth that has beenused for other kitchencleaning tasks and maycontain soil − laden detergent water. Use Elco, Bon Ami, SoftScrub, C...

Troubleshooting Procedures RS2420002 Rev. 5 14 Power Supply If no part of the cooktop operates or only part of itoperates, the cause may be a problem in the powersupply.1. Verify supply circuit breakers or fuses are not tripped. Check rating. 2. Disconnect power source. Check terminals at terminal b...

Troubleshooting Procedures RS2420002 Rev. 5 15 Multi − Position Switch Continuity Test1. Remove all wires connected to the control.2. Turn control to OFF. Check for continuity between each contact (1 − 1a, 2 − 2a, 3 − 3a, ect.) except contacts 7 − 7a. If continuity is found between any contacts, the...

Troubleshooting Procedures RS2420002 Rev. 5 16 CAKH and AKH Units Halogen Element Continuity Test1. Disconnect power from cooktop. Connect ohmmeter leads to element assembly terminals. Note that theresistive element is in series with halogen tubes. 2. Check for continuity readings on the follow elem...

Troubleshooting Procedures RS2420002 Rev. 5 17 Indicator Lights and Diode Assembly − Some Models Power Connected1. Set meter to measure at least 250 VAC. Connect one meter lead to P of control and the other to L2. 2. Connect cooktop to power source. Turn on control.3. Meter should indicate 240 VAC. ...

Troubleshooting Procedures RS2420002 Rev. 5 18 Problems Halogen Elements Quick Star Element Solid Disk Element Element burns outimmediately afterinstallation. Improper wiring installationHot Wired to Neutralterminal. Warranty isVOID.(SEE InstallationInstructions.)NOTE: Possible damage toglass. Impro...

Disassembly Procedures RS2420002 Rev. 5 20 WARNING ! To avoid electrical shock, personal injury , ordeath, disconnect power supply and removecooktop from countertop before replacing anyparts. NOTE: Lay cooktop upside down on a soft cloth. Do not rest an inverted cooktop on the control knobs orshafts...

Wiring Diagrams and Schematics RS2420002 Rev. 5 21 CAKE30W P8597905S

Wiring Diagram and Schematics RS2420002 Rev. 5 22 AKH30AKH35 P8597801SP8597802S