Bard FH110D60F - Manual

Bard FH110D60F

Bard FH110D60F – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
Page: / 42

Table of Contents:

  • Page 2 – CONTENTS
  • Page 3 – GETTING OTHER INFORMATION and PUBLICATIONS
  • Page 4 – INSTALLATION and OPERATING INSTRUCTIONS; EQUIPMENT SELECTION; Do not; LOCATING THE FURNACE; Clearance from combustible material as; TABLE 1
  • Page 5 – IF
  • Page 6 – FRONT VIEW; LEFT SIDE VIEW
  • Page 7 – FIGURE 3; BOTTOM VIEW; COUNTERFLOW
  • Page 8 – IMPORTANT; INSTALLING THE FURNACE; INSTALLATION; DUCT WORK; NOTE: IF DRAIN PAN IS ANYTHING OTHER
  • Page 9 – WIRING; FACTORY WIRING
  • Page 10 – ALL WIRING MUST; WARNING; FIGURE 4
  • Page 11 – FIGURE 5; Follow all appropriate
  • Page 12 – FIGURE 6
  • Page 13 – BECKETT “CLEANCUT” OIL PUMP; Inspect firepot refractory
  • Page 14 – PRIMARY OPERATIONAL GUIDE
  • Page 15 – TABLE A
  • Page 17 – CAUTION
  • Page 19 – Check all oil lines and connections for leaks.
  • Page 21 – Measure Stack Temperature
  • Page 23 – FIGURE 9; Pressure Gauge
  • Page 25 – SPACING OF ELECTRODES; COMBUSTION AIR REQUIREMENTS; ELECTRODE ADJUSTMENTS — AFG BURNERS
  • Page 26 – COMBUSTION AIR BOOT ASSEMBLY; AFG BURNER
  • Page 27 – all
  • Page 29 – APPLIANCES LOCATED IN CONFINED SPACES
  • Page 30 – VERTICAL VENTING; THERMOSTAT
  • Page 31 – TEMPERATURE RISE RANGES, LIMIT CONTROL SETTINGS,
  • Page 32 – AIR FILTERS; See Table 11 for filter sizes and quantities.; Optional; FILTER SIZES FOR OIL FURNACES; Filter; TYPICAL INSTALLATION OF FR26 AND
  • Page 33 – LO-BOY MODELS – FILTER LOCATIONS; FILTER INSTALLATION – LO-BOY MODELS; UNIT FILTER
  • Page 34 – MAINTENANCE; LUBRICATION
  • Page 35 – BURNER REMOVAL; ENOUGH TO ROTATE; DANGER; REMOVAL OF BURNER ONLY
  • Page 36 – TO REMOVE BURNER ONLY; BE CAREFUL NOT TO TIP ASSEMBLY; BURNER AND COMB. CHAMBER; IN THE TOP LEFT; REMOVAL OF ENTIRE COMBUSTION CHAMBER MOUNTING SYSTEM
  • Page 37 – CARE OF FINISH; COMMON CAUSES OF TROUBLE; Do not adjust this control
  • Page 38 – BLOWER SYSTEM RESISTANCE CHARTS
  • Page 39 – CHART 7
  • Page 40 – NOTES
  • Page 41 – UNI
Loading the manual

Manual 2100-422M
Page

1 of 42

FH085D36F

FH110D48F

FH110D60F

FLF085D36F

FLF110D48F

FLF110D60F

FLR085D36F

FLR110D48F

FLR110D60F

FLR140D60F

FC085D36F

FOR YOUR SAFETY

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE
VICINITY OF THIS OR ANY OTHER APPLIANCE.

IMPORTANT NOTICE

THIS FURNACE IS NOT INTENDED FOR USE AS A CONSTRUCTION HEATER. USE OF THIS
FURNACE DURING CONSTRUCTION AND FINISHING PHASES OF A STRUCTURE IS
CONSIDERED AS "OPERATION IN A CORROSIVE ATMOSPHERE" AND "UNUSUAL,
NEGLIGENT OR IMPROPER USE" AND AS SUCH ARE CONSIDERED EXCLUSIONS BY THE
BARD MANUFACTURING COMPANY LIMITED WARRANTY.

WARNING

CARBON MONOXIDE POISONING HAZARD

FAILURE TO FOLLOW THIS WARNING COULD RESULT IN PERSONAL INJURY OR DEATH.

Carbon Monoxide is invisible, orderless and toxic! Bard Manufacturing recommends a carbon
monoxide alarm in your home, even if you do not own a gas appliance. Locate the carbon
monoxide alarm in the living area of your home and away from doorways to attached garages.
Follow the alarm manufacturer’s instructions included with the alarm.

WARNING

READ ALL INSTRUCTIONS CAREFULLY BEFORE BEGINNING THE INSTALLATION.

THIS INSTALLATION MUST COMPLY WITH THESE INSTRUCTIONS AND THE REQUIREMENTS
OF ALL GOVERNING CODES AND ORDINANCES FOR THE INSTALLATION LOCATION.

IT IS THE RESPONSIBILITY OF INSTALLER TO KNOW AND UNDERSTAND ALL OF THESE
REQUIREMENTS.

FAILURE TO DO SO COULD CREATE A HAZARD RESULTING IN PROPERTY DAMAGE, BODILY
INJURY OR DEATH.

OIL FURNACE

INSTALLATION INSTRUCTIONS

Manual:

2100-422M

Supersedes:

2100-422L

File:

VOL. I, TAB 3

Date:

11-21-11

Bard Manufacturing Company, Inc.
Bryan, Ohio 43506

Since 1914...Moving ahead just as planned.

MODELS

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - CONTENTS

Manual 2100-422MPage 2 of 42 CONTENTS Getting Other Information and Publications ........ 3 Installation and Operating Instructions Equipment Selection ............................................. 4Locating the Furnace ............................................ 4Installing the Furnace ..............

Page 3 - GETTING OTHER INFORMATION and PUBLICATIONS

Manual 2100-422M Page 3 of 42 GETTING OTHER INFORMATION and PUBLICATIONS These publications can help you install the furnace. Youcan usually find these at your local library or purchasethem directly from the publisher. Be sure to consultcurrent edition of each standard. National Fuel Gas Code .........

Page 4 - INSTALLATION and OPERATING INSTRUCTIONS; EQUIPMENT SELECTION; Do not; LOCATING THE FURNACE; Clearance from combustible material as; TABLE 1

Manual 2100-422MPage 4 of 42 INSTALLATION and OPERATING INSTRUCTIONS EQUIPMENT SELECTION An accurate heating load calculation must be conductedusing American Society of Heating, Refrigeration andAir Conditioning Engineers (ASHRAE) or AirConditioning Contractors of America (ACCA)manuals. Do not add a...

Other Bard Models

All Bard Other