Baldor AE11 - Manual

Baldor AE11

Baldor AE11 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
71 Page 71
72 Page 72
73 Page 73
74 Page 74
Page: / 74

Table of Contents:

  • Page 3 – Table of Contents
  • Page 5 – Safety Notice
  • Page 6 – Symbols; Precaution Statements Used In This Manual; IMPORTANT SAFETY INSTRUCTIONS; operation of the generator are as described in this manual.
  • Page 7 – Product Safety Information 1-3; Operation Warning Statements; Continued; loose clothing or extremities and cause serious or fatal injury.; Continued on next page.
  • Page 10 – -6 Product Safety Information
  • Page 11 – General Information 2-1; Limited Warranty; Warranty Period; Generator Series
  • Page 12 – -2 General Information
  • Page 13 – Receiving & Inspection; the commercial carrier that delivered your system.; Lifting the Generator; Figure 3-1 Generator Lifting & Mounting; Lift Point
  • Page 14 – Physical Location; under the generator set.
  • Page 16 – Indoor Location; Installation; State. Installation generally includes the following:; Secure the Generator; remove the shipping pallet.; Table 3-1 Physical Dimensions; NG
  • Page 17 – Generator Model; General Considerations
  • Page 18 – Pipe; gas connections comply with all building codes.; Figure 3-2 Gas Line Connections
  • Page 19 – The incoming pressure must be as indicated in Table 3-2.; Table 3-4 LP Gas Flow Rate (Cubic Feet per Hour) per Pipe Length; Do Not guess, be sure pipe size is adequate for required flow rate.
  • Page 21 – Applies only to AE8 Enclosed and Open Series Generators; AE8 with Enclosure or Open; Generator; control circuits allow the engine to run for approximately 60; with Enclosure
  • Page 22 – AE10 Electrical Connections; Applies only to AE10 Enclosed and Open Series Generators; Single Phase Power Connections; AE10 with Enclosure; Remote Start and Battery Charger Connections; Figure 3-6 Remote Start & Battery Connections
  • Page 23 – AE11 Electrical Connections; Applies only to AE11 Enclosed Series Generators; AE11 with Enclosure; Figure 3-8 Remote Start & Battery Connections; TBP; Natural Gas
  • Page 24 – AE25 Electrical Connections; Applies only to AE25 Enclosed Series Generators; Load; Figure 3-10 Remote Start & Battery Connections
  • Page 25 – a common Ground and neutral.; Figure 3-11 Frame Ground Connection; Earth Ground; Engine Oil Level; Check the engine oil level, it should be empty.; Coolant Level; Check the coolant level while the engine is cold, it should be full.
  • Page 27 – Figure 3-12 Battery Installation; Connect the negative lead to the negative (; Recommended Engine Oil and Battery Type; Interstate SP−40
  • Page 29 – Post Installation Checks
  • Page 31 – This will be used to explain how the controls operate.
  • Page 32 – Hour Meter
  • Page 36 – Programmable Functions and Values
  • Page 37 – Immediate Warning Close on Fault
  • Page 38 – Auxiliary Output 1
  • Page 39 – Pin No; Garretson Model KN Fuel Valve Considerations; pressure vaporized; Operation; service the KN until you are sure it is needed.
  • Page 41 – Troubleshooting and Maintenance 5-1; Maintenance; precedence over any of the following general recommendations.
  • Page 42 – -2 Troubleshooting and Maintenance; Problems and Solutions; to the Baldor Generator Service Department by calling (920) 236; Table 5-1 General Troubleshooting Guide; Problem
  • Page 43 – Troubleshooting and Maintenance 5-3; Note: Table 5-2 is provided as a guide check
  • Page 44 – Service; Parts; information available prior to contacting the factory:
  • Page 45 – Information in this Appendix applies to the AE8 Generator.; Operator Panel Configuration; Master Control Switch
  • Page 46 – Replacement Parts; was provided with your generator set.; Figure A-2 Alternator Assembly
  • Page 47 – Table A-1 Generator Set Parts List; Wiring Diagrams
  • Page 48 – Figure A-4 AE8 Customer Connection Diagram
  • Page 49 – Figure A-5 AE8 Open Frame Wiring Diagram
  • Page 50 – Figure A-6 AE8 Enclosed Wiring Diagram
  • Page 51 – Appendix B; Information in this Appendix applies to the AE10 Generator.
  • Page 52 – Figure B-2 Alternator Assembly
  • Page 53 – Table B-1 Generator Set Parts List
  • Page 54 – Figure B-4 AE10 Customer Connection Diagram
  • Page 55 – Figure B-5 AE10 Open Frame Wiring Diagram
  • Page 56 – Figure B-6 AE10 Enclosed Wiring Diagram
  • Page 57 – Appendix C; Information in this Appendix applies to the AE11 Generator.
  • Page 58 – Figure C-2 Alternator Assembly
  • Page 59 – Table C-1 Generator Set Parts List; Conversion from LPG to Natural Gas
  • Page 61 – Figure C-7 AE11 Customer Connection Diagram
  • Page 62 – Figure C-8 AE11 Generator Connection Diagram
  • Page 63 – Figure C-9 AE11 Engine Connection Diagram
  • Page 64 – Figure C-10 AE11 Connection Diagram
  • Page 65 – Figure C-11 AE11 Customer Wiring Interface Diagram
  • Page 67 – Appendix D
  • Page 68 – Figure D-2 Alternator Assembly
  • Page 69 – Table D-1 Generator Set Parts List
  • Page 70 – Figure D-4 AE25 Receptacle Connection Diagram
  • Page 71 – Figure D-5 AE25 Engine Compartment Connection Diagram
  • Page 72 – Figure D-6 AE25 Control Box Connection Diagram
  • Page 73 – Baldor District Offices
  • Page 74 – BALDOR ELECTRIC COMPANY
Loading the manual

Automatic Emergency

Generator

AE8, AE10, AE11 and AE25

Installation & Operating Manual

5/05

MN2415

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - Table of Contents

Table of Contents Table of Contents i MN2415 Section 1 Product Safety Information 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Notice 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . ...

Page 5 - Safety Notice

Section 1 Product Safety Information Product Safety Information 1-1 MN2415 Safety Notice Be sure that you are completely familiar with the safe operation of this equipment. This equipment may be connected to other machines that have rotating parts or parts that are controlled by this equipment. Impr...

Page 6 - Symbols; Precaution Statements Used In This Manual; IMPORTANT SAFETY INSTRUCTIONS; operation of the generator are as described in this manual.

1-2 Product Safety Information MN2415 This symbol is shown throughout the manual to indicate a connection to ground reference point. Symbols Indicates a potentially hazardous situation which, if not avoided, could result in injury or death. Indicates a potentially hazardous situation which, if not a...

Other Baldor Models

All Baldor Other