Axor 6405000 Manual - Free PDF Download

Page 2 - ThermoBalance II Deck Valve

2 ThermoBalance II Deck Valve 06401XX0 Metris S 06405000 Focus S 06450XX0 Solaris E 06451XX0 Stratos E 06452XX0 Metro E 06453XX0 Talis S 06450XX0 06451XX0 06452XX0 06453XX0 06454XX0 06455XX0 06456XX0 06401XX0 06405XX0 06454XX0 C Cross 06455XX0 C Scroll 06456XX0 C Lever 04172XX0 Solaris² E 04185XX0 A...

Page 3 - Do not plug either outlet.

3 04198XX0 04172XX0 04185XX0 Technical Specification Recommended pressure 45 - 72 psi Maximum hot water temp. 165° F* Recommended hot water temp. 120° - 140° F* Flow rate @ 44 PSI 8 gpm Safety stop 100° F 1/2" female NPT inlets Maximum mounting surface thickness 1 3/8" Hole size in mounting ...

Page 4 - Install the rough; Install the plaster shield.

4 Install the rough Rest the rough on the mounting surface.Tighten the lower mounting ring and washer. Tighten the tensioning screws. Install the plaster shield. Remove the upper mounting ring.Screw the lower mounting ring and washer to their lowest position.Insert the rough up through the hole. Ins...

Page 5 - Install the hot and cold water supply; Wrap the threads on the hot and cold supply pipes; Install the outlet lines*; If only one outlet is to be used,; hot inlet

5 If the supplies are not connected to the correct inlets, the valve cannot function properly! Both outlets must be plumbed! Install the hot and cold water supply lines* Wrap the threads on the hot and cold supply pipes with Teflon tape. Install the hot and cold supplies to the corresponding inlets....

Page 6 - slot

6 Install the valve trim Remove the plaster shield. Push the escutcheon over the valve.Install the handle. Tighten the screw with a 3 mm Allen wrench. The screw must engage the slot on the cartridge.Justify the handle.Set the high temperature limit stop, if required. Justify the handle Turn the wate...

Page 7 - Set the high temperature limit stop (optional); Hold the handle lever in one hand.

7 Set the high temperature limit stop (optional) Turn the water on to the tub spout or handshower. Use a 3 mm Allen wrench to loosen the handle screw. Remove the handle from the valve. Carefully remove the retainer clip and the limit stop ring (1). Turn the temperature control stem until the water i...

Page 8 - Maintenance: Clean the filters; Failure to hold the stop unit steady

8 Maintenance: Clean the filters CAUTION: Turn off the water at the main or with the service stops, before opening the valve.Remove the handle and escutcheon. Failure to hold the stop unit steady while unscrewing or replacing the thermostat cartridge will result in damage to the stop unit. Grasp the...

Page 9 - User instructions

9 Justify the handle. User instructions From the off position, turn the diverter lever clockwise or counter-clockwise to obtain water from either of the two functions. Turn the temperature control knob clockwise to make the water cooler. Turn it counter-clock- wise to make the water warmer. When tur...

Page 10 - Replacement parts

10 1 cartridge with shutoff unit 88586000 2 thermostat cartridge 94282000 3 Solaris handle 88528XX0 4 Stratos handle 88543XX0 5 Metro handle 88548XX0 6 Talis handle 88549XX0 7 Cross handle 88608XX0 8 Scroll handle 88609XX0 9 Lever handle 88610XX0 10 Metris handle 11 Focus handle 12 escutcheon 13 All...