Page 3 - Burning Appliances and Equipment.; WARNING
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 70400101 (EN) 1 Installation must conform with local codes or in the absence of local codes with:In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/ NFPA 54 “National Fuel Gas Cod...
Page 4 - Table of; Introduction
© Copyright 2011, Alliance Laundry Systems LLCAll rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 2 70400101 ...
Page 5 - Model Identification; Information in this manual is applicable to these models:; Gas
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 3 70400101 (EN) Introduction Model Identification Information in this manual is applicable to these models: Includes models with control suffixes: Gas Steam Electric T30 CHD30STG2-CAT30LCHD30STG2-CAT30NCHD30STG2-CTT30LCHD30STG2-CTT3...
Page 6 - Customer Service; Wiring Diagram
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Introduction 70400101 (EN) 4 Customer Service If literature or replacement parts are required, contact the source from which the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address of...
Page 7 - Safety Information; Explanation of Safety Messages; Installation Manual; DANGER
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 5 70400101 (EN) Safety Information Explanation of Safety Messages Precautionary statements (“DANGER,” “WARNING,” and “CAUTION”), followed by specific instructions, are found in this manual and on machine decals. These precautions ar...
Page 8 - Important Safety Instructions; Hazardous Voltage. Can cause shock, burn
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Safety Information 70400101 (EN) 6 Important Safety Instructions Save These Instructions 1. Read all instructions before using the tumble dryer. 2. Refer to the GROUNDING INSTRUCTIONS for the proper grounding of the tumble dryer. 3....
Page 9 - DO NOT; To reduce the risk of serious injury, install
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Safety Information 7 70400101 (EN) 23. Remove laundry immediately after tumble dryer stops. 24. Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce...
Page 10 - Figure 2; Operating Instructions; Step 3: Determine Control Type and; To reduce the risk of fire:
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 70400101 (EN) 8 Operating Instructions Emergency Stop Button on CE Models All CE approved OPL tumble dryers are factory equipped with an emergency stop button located on the front panel. Refer to Figure 2 . Figure 2 To operate emerg...
Page 11 - Control Instructions; LED OPL Control; EO Control Suffix; Programming
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 9 70400101 (EN) Control Instructions Figure 3 LED OPL Control EO Control Suffix 1. Press the Up ( ) or Down ( ) keypad to change cycles.To customize a cycle, refer to the Programming Manual . 2. Press Start ( ...
Page 12 - Dual Digital Timer Control; QT Control Suffix; Set the HEAT TIME for the number of minutes
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 70400101 (EN) 10 Figure 4 Dual Digital Timer Control QT Control Suffix 1. Select HIGH, MED, LOW or NO HEAT by turning the temperature knob.HIGH temperature 190°F (87°C)MED temperature 170°F (77°C)LOW temperatu...
Page 13 - Lr
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 11 70400101 (EN) IMPORTANT: To stop the tumble dryer at any time during the cycle, OPEN DOOR. If the loading door or lint panel door is opened during the cycle, the heating system will shut off and the motor w...
Page 14 - Error Codes; • Disconnect electric power to the tumble dryer before servicing.
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 70400101 (EN) 12 Error Codes Display Definition Corrective Action OP Open thermistor error • Check thermistor. Replace if inoperative.• Check wiring diagram between control and thermistor. Refer to wiring diag...
Page 15 - Single Drop Control; SD and SX Control Suffixes; Ready Mode; IN USE; Run Mode; IN
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 13 70400101 (EN) Figure 5 Single Drop Control SD and SX Control Suffixes 1. Select HIGH, MED, LOW or NO HEAT by turning the temperature knob.HIGH temperature 190°F (87°C)MED temperature 160°F (71°C)LOW tempera...
Page 16 - NOTE: To change dipswitch settings refer to; To Program a Short Test Cycle:; NOTE: With all control dip switches off, the total
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 70400101 (EN) 14 Door Open Mode In Door Open Mode, the control turns off the heater and motor when the door is opened during a run cycle. The timer will continue to count down time and the IN USE LED is lit. E...
Page 17 - DX4 Coin Control; V and 3X Control Suffixes; select a cycle and start the tumble dryer. Refer to; NOTE: Drying times will be dependent on the; When the cycle is complete, open door and
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 15 70400101 (EN) Figure 7 DX4 Coin Control 3V and 3X Control Suffixes 1. Open door and fill drum with clothes.2. Close door.3. Insert the coin(s) in the coin slot.4. Press and release one of the cycle buttons ...
Page 18 - DX4 OPL Control; O Control Suffix; IMPORTANT: To stop the tumble dryer at any; When the cycle is complete, open door and
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 70400101 (EN) 16 Figure 8 DX4 OPL Control 3O Control Suffix 1. Open door and fill drum with clothes.2. Press and release one of the cycle buttons to select a cycle and start the tumble dryer. Refer to Table 3 ...
Page 21 - System Tests; Unexpected Presence of Flame; Figure 9
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Operating Instructions 19 70400101 (EN) System Tests The following system tests are performed during normal operation. System tests are performed at a minimum of every 24 hours. Low Voltage Detection If the voltage between terminals...
Page 22 - Maintenance; Daily
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 70400101 (EN) 20 Maintenance Daily 1. Inspect the area surrounding tumble dryers, remove all combustible materials, including lint, before operating the machine. 2. Check cylinder for foreign objects to avoid damage to clothing and ...
Page 24 - Monthly
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Maintenance 70400101 (EN) 22 Monthly 1. Remove lint and debris from inside exhaust duct to maintain proper airflow and avoid overheating. a. Remove external duct and duct access covers, if present. b. Clean inside of duct with a vac...
Page 25 - Daily Maintenance
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Maintenance 23 70400101 (EN) Daily Maintenance Monthly Maintenance To reduce the risk of electric shock, fire, explosion, serious injury or death: • Disconnect electric power to the tumble dryer before servicing. • Close gas shut-of...
Page 26 - Quarterly Maintenance
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Maintenance 70400101 (EN) 24 Quarterly Maintenance To reduce the risk of electric shock, fire, explosion, serious injury or death: • Disconnect electric power to the tumble dryer before servicing. • Close gas shut-off valve to gas t...
Page 27 - Bi-Annually Maintenance
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Maintenance 25 70400101 (EN) Bi-Annually Maintenance Annual Maintenance To reduce the risk of electric shock, fire, explosion, serious injury or death: • Disconnect electric power to the tumble dryer before servicing. • Close gas sh...
Page 28 - Before You Call for Service; If literature or replacement parts are required, contact
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Before You Call for Service 70400101 (EN) 26 Before You Call for Service Customer Service If literature or replacement parts are required, contact the source from which the machine was purchased or contact Alliance Laundry Systems a...
